Embedded Files
168 Brookstead Rd
All contractors and visitors to the Brookstead Run Off Block must either sign in and out using the link above or by text to Blair on 0274 431 709 when arriving and leaving. The exception is if your vehicle fleet is tracked by company GPS.
Contractors visiting Marchwood or Awamoko dairy farms must sign in and out using the relevant systems for those farms, or by contacting James (Awamoko) on 027 215 8266, or William (Marchwood) on 021 026 20298.
Please read all General Hazards below and the Hazard Maps then read the hazards for the relevant work areas below before you commence work.
Click here for Workshop Hazards
If you are going to be using machinery please read about the Vehicle and Machinery Hazards and ensure you have the appropriate training.
All hazards are subject to change and where possible those changes will be updated on this site and existing contractors notified. However, care must be taken at all times as this is not an exhaustive list. Expect the unexpected and report any incidents or accidents. We will investigate incidents in order to find ways to prevent them happening again. The policies you read here are often the results of previous accidents and incidents including some on this farm. To encourage full and open reporting we operate a 'just culture' where investigations not used to inform disciplinary procedures unless malice is involved. Please also report any changed or new hazards you may notice or incidents that occur. You can do so anonymously by clicking here if you prefer. We are open to all suggestions how to make the farm safer.
General Hazards
General Hazards
Steep and sometimes slippery slopes - including on lanes. High risk of slides and collision. If the cow lanes are slippery use a quad bike or tractor rather than ute or two wheeler if attempting a slope.
Irrigation and rainfall will increase the risk of loss of control.
Wear a seat belt.
Use alternative routes if there is any possibility of loss of traction.
Use two wheel motorbikes wherever possible as there is less risk if you fall off compared with other vehicles such as quads.
Always consider what your options are if you were to start sliding. Maintain a run-out when on slopes.
Some paddocks have steep drops - particular care is required in all paddocks at night or in other low visibility conditions. New under runners can develop after rain.
Uneven, rough or soft and boggy ground. High risk of losing control, collision or roll-over. These hazards can be anywhere and develop any time. Report any holes or bogs to management to be fixed.
Pivot ruts can develop which may cause loss of control or roll over.
Waterways - various unfenced ponds with soft bottoms present a high drowning risk, as does the Awamoko stream. Children under the age of eight are to be supervised directly by someone over the age of sixteen.
Flooding occurs on the Awamoko. Stay out of flood waters unless it is more hazardous to remain in place. Human safety takes precedent over stock welfare so ensure stock are prepared on high ground ahead of time to prevent the motivation for people to enter flood waters. Use high roads to town if travel is necessary.
Fire - high risk in vegetation and buildings. Irrigation offtakes can be used as a firefighting water source, as can the Awamoko Creek.
Heavy machinery operating - particularly trucks and tractors. High risk of collision. Keep left on lanes. Use rotating beacon if fitted.
Other workers at all times. Their actions may put you at high risk in many ways and vice versa. Communicate. Maintain low speeds, keep an eye out and expect other people to be around.
Manual Handling - medium risk of lifting injury. Use two people to lift weights over 25kg, except for calves which are safer to handle on your own due to awkward shape.
Blind corners and rises. High risk. Keep left, keep to speed limit.
Noise hazards - medium risk of hearing loss. Chainsaws, lawn mowers, power tools, tractors without cabs and other equipment exceed the safe level of noise. Hearing protection must be worn if using any loud equipment.
Chemical hazard - high explosive, fire, corrosive and toxic risks. SDS available by clicking here.
Store chemicals in original containers with warning labels showing.
Avoid contact with chemicals - particularly hormone treatments, anthelmintics and herbicides when pregnant.
Use PPE: nitrile gloves, mask, safety glasses, cotton overalls and gumboots.
Animals. Particularly hazardous when handling in cattle yards - high crushing and kicking risk. When working in the yards be aware of slippery and boggy surfaces. Follow Worksafe guidance. Be firm but quiet when working with animals, have an escape route, keep clear of kicking range and expect them to turn on you at any time.
Bulls. Maintain escape routes and always keep an eye on the bulls when working with them.
Children may be present at any place on the farm and must never be alone. If children are found alone then alert the parents immediately. High risk.
Public Roads - the farm borders Brookstead Road with entrances on blind corners and Ngapara-Georgetown Rd with high speed traffic.
Traffic on the road presents a high collision risk. Follow road rules. Keep left and allow faster traffic past. Be aware of faster traffic catching up.
Take care when pulling out with tractors as the front end loader protrudes in front.
Stock on public roads is a high collision risk. Double check that stock are locked away at night. When shifting stock on the road use the signs, rotating beacons and enough staff. Notify council. Take care when crossing stock to the Motorbike Track.
Ensure stock are well fed, watered and have good fence power to reduce risk of breakouts.
Electrical hazards - high electrocution risk. Remain 4m clear of overhead wires, particularly with telehandlers, excavators towing augers and operating front end loaders. Ensure you have clearance before driving under any wires. Look up and live.
Enquire with management over location of underground cables before digging. Note: cables may be anywhere within the width of the trench they were laid in. Browse the Network Waitaki site for public cable location and more safety info.
High pressure water - medium injury risk. All irrigation infrastructure is high pressure, is often buried and often associated with electrical hazards and made of conductive materials. Always isolate electricity and pressure before working on infrastructure.
Don't park anything in the way of the travelling irrigators.
Overground pipework - particularly hard hose. High risk of falling off two wheelers. Ride slowly and keep an eye out.
Fire extinguishers - while these are a safety feature they are also highly pressurised gas cylinders. To be handled with care. These will be maintained every five years as per law. Medium risk.
Water troughs - sometimes in the middle of a paddock. Learn the location of each trough. Medium risk. Drive slowly.
Tape gates - on elastic cord which can cause wire hooks to dig into flesh or eyes if released dangerously. Release carefully. Use safer design for future handles. Low risk.
Offal - dead animals may harbour pathogens. Remain in tractor cabin when burying cows. Hose down bucket when finished. Don't dig into compost manually without PPE. Low risk.
Fire arms - high shooting risk. Follow seven rules of firearm safety. Only licensed shooters with permission to operate firearms and trained operators to use bolt gun.
Electric Fences - low electrocution risk. Ensure visitors don't touch fences.
Environmental hazards - weather; sun, rain, snow, visibility, wind, electrical storms. Wear appropriate clothing, use sun block. High risk.
Bale stacks - may be unstable and fall. Don't climb. Don't work near them unnecessarily.
Hay barn - Particularly a risk for children climbing up and falling between.
Silos - high risk of suffocation and falls. Do not enter full silo. Only enter silos if someone is outside. Never climb silos without climbing harness, heights training and a buddy system.
Google Sites
Report abuse